LINCOLN TOWNCAR AIR SUSPENSION LIGHT

TURN CHECK AIR SUSPENSION DASH LIGHT OFF 

Vehicle model 1996 Lincoln Towncar

Hope these procedure helps to turn off the Air suspension light.

First of all access the Airsuspension module.For that you need to remove  glove box . The Air  suspension control module is mounted on the AC/Heater box .

The Module has black connector and a gray connector. 

Now here the actual procedure starts.

If you Unplug the black connector ,that it will turn off the "check air suspension light" but with that it will also disable your power steering tension (variable assist steering) control on the left side of the steering column. 

So to only turn off check air suspension light and not power steering control the trick is to  unplug the black connector and then you need to remove the dark green/light green wire pin from the connector (pin #11) and then reconnect that black connector to the module. That will disable only the check air suspension light. 

Also you can  just identify that black connector to the module and cut the green wire. And be sure to isolate that wire because the "check air suspension light" will come on if it touches ground.

==================

FOR same problem 2001 Lincoln Town Car Air Suspension Light will not go off

To turn the light off and disable the air suspension, you have to disconnect the air suspension module.
The module is located in the luggage compartment, exactly behind the air suspension switch.

To access the Suspension module pull back the wall carpet and remove the 2 nuts that hold the suspension module. Unplug the suspension module and bolt the module back in place.

But disconnecting the module connector will also disable the active steering system. 

As mentioned in the previous section on the older Lincolns you could cut a green wire and that would kill the light. The newer ones like this one have the suspension/steering module communicating over a data bus with the instrument cluster. There has to be some faking the suspension module out to get the light to stay off. The steering/suspension module on this year is located behind the dash. 

=================

FOR 2002 LINCOLN TOWN CAR WITH AIR SUSPENSION LIGHT ON

Is the vehicles ride height high or low on any corner?

Since no such air ride issues are noticed then it may something simple as just a corroded electrical connector or a air ride height sensor thats failing. To know whats wrong you must get a scan tool hooked up and retrieve the stored fault codes. The error code will point out what is causing the Suspension light to remain ON.

The suspension light come on if you either turn the system off or if its a problem in the system. Either way you are fine to go ahead and drive it with he light on as long as it hold ride height till you can get it in for repair.

===================

These details will help.
Thanks.

Users Who Viewed This Problem Also Viewed:

2005 Lexus RX300: Rear Suspension Makes Noise while Driving Over Hump?

http://whatisbyme.blogspot.in/2012/05/2005-lexus-rx300-rear-suspension-makes.html

Front Suspension diagrams?

http://howtobyme.blogspot.in/2012/02/front-suspension-diagrams.html

Blue Water Warning Light on Dash?

VEHICLE: Volkswagen Beetle 2000 Year model.

PROBLEM:  Warning light comes up on dash while driving.Its blue light .It shows sign of water.

TROUBLESHOOTING SOLUTION DETAILS:

Its a warning light to indicate you the problem.

The blue water Warning light is for the low coolant level.
The warning light says then coolant level is low in your car then required.Either its leaking or its got low by natural way which happens by time.After few moths the coolant needs to be filled.So first check that the coolant is up to the mark on the translucent tank
If the coolant is LOW,then get the coolant line pressure tested by pressure tool.The tool can be easily available at local auto part stores.If pressure is not leaking then refill the coolant in its reservoir.

But If coolant is properly full and up to its mark  then its possible that the coolant level switch / sensor is faulty or stuck.

For that issue you need to try unplugging the coolant level switch/sensor.
On VW beetle the coolant level switch/sensor is located  on the side of the tank.
Properly check that its connection is bright and clean and that the wire is not damaged/loose or worn out.
If this seems Ok then you can remove the level switch and give it a good clean with fresh water to ensure its de-scaled.
Then reconnect and check.
All should be good.

These details will help.
Thanks.

Users Who Viewed This Problem Also Viewed:

Coolant Level Sensor on Audi A4?

http://repairhelpcenter.blogspot.com/2011/11/coolant-level-sensor-on-audi-a4.html

1989 Ford Taurus: Engine Coolant Temperature Sensor Testing?

http://whoisbyme.blogspot.in/2012/06/1989-ford-taurus-engine-coolant.html

1991 Toyota Camry: Order Coolant Bypass Tube?

http://whatisbyme.blogspot.in/2012/05/1991-toyota-camry-order-coolant-bypass.html

1994 Toyota Camry: Coolant Leak?

http://technoanswers.blogspot.in/2012/04/1994-toyota-camry-coolant-leak.html

2006 Cadillac DTS: COOLANT LEAK AT DRIVER SIDE NEAR FIREWALL?

http://schematicsdiagram.blogspot.in/2012/04/2006-cadillac-dts-coolant-leak-at.html

MAF, IAT, MAP and Coolant Level Sensor problem all together on Mazda MPV?

http://schematicsdiagram.blogspot.com/2011/12/maf-iat-map-and-coolant-level-sensor.html

GMC Engine Coolant Temperature (ECT) Sensor Replacing?

http://schematicsdiagram.blogspot.com/2011/12/gmc-engine-coolant-temperature-ect.html

Loosing Coolant?

http://whoisbyme.blogspot.in/2012/06/loosing-coolant.html

Coolant temperature sensor dies again and again?

http://schematicsdiagram.blogspot.com/2012/01/coolant-temperature-sensor-dies-again.html

2000 Daewoo Lanos: Where to Add Coolant?

http://repairhelpcenter.blogspot.in/2012/06/2000-daewoo-lanos-where-to-add-coolant.html

Toyota Prius: Hybrid Warning Light?

It can be related to the 12v battery being low especially if it should the park on level ground warning. This usually means the 12v battery is falling and this in turn causes communication errors and codes in the HV system. Auto Zone can read the Engine computer codes nothing else but that is free and there may be some codes there that can help and try and save you some $$ They can test the 12 battery also. It may not be as good as the dealer but is free.

The problem started after Replacing Drivers side running lights:---
No it is not likely an issue with the lights. The HID lights had a corrosion issue with the level sensor but that shows a warning light on the display indicating a problem in the light system. Bulbs can not affect the HV systems.


This details will help.
Thanks.

For All types of Car models and brands help 
Go to Newly Launched

FREE Car repair guide? 
http://technoanswers.blogspot.in/2012/03/car-repair-guide.html 

& 
Complete Car repair Help FREE? 

http://repairhelpcenter.blogspot.in/2012/03/complete-car-repair-help.html